| 超滤处理洗涤污水循环利用的中试研究 |
| 摘要点击 1426 全文点击 1918 投稿时间：2006-02-08 修订日期：2006-04-20 |
| 查看HTML全文
查看全文 查看/发表评论 下载PDF阅读器 |
| 中文关键词 超滤 洗涤污水 循环利用 膜污染 紫外消毒 阴离子表面活性剂（LAS） |
| 英文关键词 ultrafiltration(UF) laundry wastewater recycling and reuse membrane fouling ultraviolet(UV) disinfection anionic surfactant (LAS) |
|
| 中文摘要 |
| 采用不同材质国产超滤膜聚丙烯（PP）、聚丙烯腈（PAN）和聚砜（PS），进行了洗涤污水处理循环利用的现场中试研究.结合超滤工艺出水水质和膜污染分析，3种膜材质中PAN膜较优，有效去除了水中浊度、悬浮物、油脂等污染物，一定程度保留了游离阴离子表面活性剂（LAS），长期循环洗涤对衣物的白度无不良影响.根据相关性分析，超滤出水较高COD值很大程度上是由水中LAS引起的.超滤膜对细菌、大肠菌群的去除率较低，出水通过紫外消毒，当紫外线密度≥3?750 J/m2时，微生物水平能够达到国家饮用水水质标准.根据不同水力反冲洗条件下膜渗透通量和净产水量比较，PAN膜最佳水力反冲洗条件为0.5 h反冲洗2 min.长期运行时超滤膜化学清洗方法采用碱洗法方便有效. |
| 英文摘要 |
| A pilot study of the treatment for laundry wastewater recycling and reuse on the spot was carried out by ultrafiltration(UF) with different membrane material of PAN、PS and PP.According to the analysis of membrane fouling combined with UF effluent quality,PAN membrane was superior to the others.It removed the turbidity,suspended solid,fat oil and grease effectively,but kept anionic surfactant (LAS) to a certain degree in the UF effluent which is beneficial to recycling and reuse.By correlation analysis,it was found the high COD concentration of effluent was caused by LAS remained.The whiteness and softness of cotton cloth washed by UF effluent for a long term was not different with that washed by tap water.The removal of bacteria and E.coli by UF membrane was not very high,and so UF effluent was disinfected by ultraviolet(UV) further.As the dosage of UV was not less than 3?750 J/m2,the microbial level reached the China national standard of drinking water.The optimal UF operation condition is to backwash two minutes every thirty minutes' filtration.Adopted alkali liquor of pH 11 to 13 to carry out chemical cleaning,the membrane flux was recovered completely. |
