| 含铜尖晶石催化剂在苯酚催化湿式氧化降解中铜溶出的研究 |
| 摘要点击 3162 全文点击 3223 投稿时间：2007-09-13 修订日期：2007-11-12 |
| 查看HTML全文
查看全文 查看/发表评论 下载PDF阅读器 |
| 中文关键词 催化湿式氧化 苯酚 溶出 尖晶石 |
| 英文关键词 catalytic wet air oxidation phenol leaching spinel |
| DOI 10.13227/j.hjkx.20080922 |
|
| 中文摘要 |
| 利用溶胶-凝胶法制备了Cu0.10Zn0.90Al1.90Fe0.10O4尖晶石结构催化剂,并用于苯酚的催化湿式氧化降解反应， 考察了催化剂在H2-TPR实验中的氧化-还原性能, 苯酚作为还原剂、反应温度和苯酚/催化剂质量比对铜离子溶出量的影响. 结果表明，在较低反应温度或较高苯酚/催化剂质量比的情况下,被还原的催化剂活性组分不易被再氧化是导致铜离子大量溶出的主要因素.当反应温度较高和苯酚/催化剂质量比较低时,铜离子溶出量显著减少. 在190℃、苯酚浓度为4.29 g·L-1、催化剂用量为25 g·L-1的条件下反应2h, 铜离子溶出量仅为0.96 mg·L-1. |
| 英文摘要 |
| Cu0.10Zn0.90Al1.90Fe0.10O4spinel type catalyst prepared by sol-gel method was tested for catalytic wet air oxidation of phenol. The performances of Cu0.10Zn0.90Al1.90Fe0.10O4catalyst in TPR experiment, the influence of phenol as reducer, reaction temperature and phenol-to-catalyst mass ratio on copper leaching were checked respectively. According to the experimental results, it is suggested that the reduced active species can not be easily re-oxidized under low reaction temperature and high phenol-to-catalyst mass ratio are the main reasons for copper leaching. Under high enough reaction temperature and low phenol-to-catalyst mass ratio, the copper leaching reduces remarkably. At 190℃ in the presence of 100 mL aqueous solution of 4.29 g·L-1of phenol and 2.5 g catalyst, the copper leaching was only 0.96 mg·L-1after 2 h of reaction. |
|
|
|
